Metering 522r3y

Radiocrafts Embedded Wireless Solutions

Open wireless standards Wireless M-Bus, KNX RF, ZigBee, 6LoWPAN Hallvard Moholdt, Technical Solutions Manager Ørjan Nottveit, Product Line Manager

www.radiocrafts.com

Agenda AMI overview Wireless M-Bus NTA8130 OMS

KNX RF ZigBee Total cost of ownership (TCO) Q&A

AMI WAN

NAN

HAN/LAN

HAN/LAN

Gateway

Why open standards Open standards enable interoperability Open standards give multi-vendor ecosystem and hence lower cost What are open standards EN/IEC/ISO IETF Industry standard

Wireless M-Bus

figawa,

© Radiocrafts AS

Wireless M-Bus 3 Key points

Only European Norm for wireless metering Field proven in millions of meters ed by all major metering companies in Europe

© Radiocrafts AS

Wireless M-Bus Basics  Slaves reporting to Master (concentrator)  Slave receives acknowledge with minimum time response

Message decryption and acknowledge within 2-3 ms

Meter wakes up and transmits reading (gas: each 30 min)

Ack can contain ’shut valve’ command

Water: TX each 4 hours (with random time-spread)

Background  Standardization work -> Cenelec, TC 294  EN 13757 standard “Comm. Syst. for remote reading of meters”

 EN13757-4:2005: Wireless Meter Readout  -3 M-Bus application layer  -1 DLMS application layer

 The Netherlands: NTA8130 as of Feb 2006 (last revision of Jan 2009)  : OMS specification released September 2009  TC 294 again active (re-launched July 2009)

EN13757-4:2005  “Stationary Mode” S  Unidirectional, S1, or bi-directional, S2  32.768 kb/s, 868.3 MHz

 “Frequent transmit mode” T  Unidirectional, T1, or bi-directional, T2  100kb/s, 868.95 MHz

 “Frequent receive mode” R  10 channels, 4.8 kb/s

NTA 8130 (DSMR)  Netherlands Technical Agreement 8130  Dutch Smart Meter Requirements  P2 interface  Max 4 metering instruments and/or grid company equipments in each metering system  Defines T1 / T2 and AES128

OMS  Open Metering System specification  Assured co-existence with NTA 8130 / DSMR  Unified approach for the different media (electricity, gas, heat and water) as well as actuators and displays  Interoperation  Optimized for battery lifetime of > 14 years  Installation ed

OMS cont.  MUC (Multi Utility Controller): Intelligent concentrator between AMM and the devices  Either S or T mode and AES 128 encryption MUC <-> meters  OMS is being reviewed by CEN as European new work item proposal TC294

System topology

RC1180-MBUS module  Embedded protocol  ing EN 13757-4:2005 mode S, T and R2

 AES 128 HW co-prosessor  12.7 x 25.4 x 3.3 mm  compact module for SMD mounting

 No configuration required  4 pins + gnd connection  2.0 – 3.6 V supply voltage  ultra low power modes

RC1180-MBUS module  2 channels in mode S and T  868.3 and 868.95 MHz

 10 channels in mode R2  868.03 + n x 0.06 MHz

 CE marked  Conforms with EU R&TTE directive  EN 300 220, EN 301 489, EN 60950

 Designed for EX compliance  High temperatures

Feature sets standard Feature List

Feature set RC1180-MBUS1

RC1180-MBUS2

RC1180-MBUS3

General

Basic wireless M-bus functions, flexibility.

Added features for NTA8130/DSMR compliance (the Netherlands)

Added features for Open Metering System compliance ()

Network role

Master or Slave

Master or Slave

Master, Slave or Repeater

Modes

S1, S2, T1, T2, R2

T1, T2

S1, S2, T1, T2

Encryption

No, must be handled externally

Yes, AES128 according to NTA8130/DSMR (mode 4 and 5)

Yes, AES128 according to Open Metering System specification (mode 5)

Installation mode

No, Must be handled externally

Yes, according to NTA8130/DSMR. Up to 8 slaves.

Yes, according to Open Metering System specification. Up to 64 slaves.

Features

Receives any MBUS packet. Message filtering must be handled externally

Filter function: Master only receives messages from installed/ed meters

Filter function at master. Automatic access number handling and accessibility check. Autonomous Repeater.

Automatic acknowledge Message mailbox

No, must be handled externally

Yes, automatic acknowledge by Master in T2 mode

Yes, automatic message generation and message mailbox in Master for T2/S2.

High-end performance  Output power typical 10 dBm  Excellent receiver sensitivity  Typical -102 dBm at 32.768 kbps

 Excellent blocking  >-45 dBm at 2 MHz offset

 Two way communication simplifies installation compared to only one-way  8-900m range / quarterwave antenna

20

UART : Data in – RF out

Wireless M-Bus communication modem EN 13757-3

EN 13757-4

Customer Application Microcontroller

UART

GPRS modem UART

Ethernet gateway

UART

22

M-Bus application module Pulse input

Innstallation button input

Status LED output

UART for reading meter info

 Tailoring to different end s requirements

23

MUC platforms: RC1180-MBUS+ GPRS/GSM / Ethernet

RC1180-MBUS

PC Suite w/Packet sniffer

Man. ID

KNX is a ed Trademark of the KNX Association cvba, used with kind permission

© Radiocrafts AS

KNX RF + wireless M-Bus

= a complete solution for

building automation and load management

&

home area metering

KNX is a ed Trademark of the KNX Association cvba, used with kind permission

 KNX is the worldwide standard for home and building control (~7000 certified products)  IEC/ISO and EN standard  ing media (RF, PL, TP, IP)

KNX is a ed Trademark of the KNX Association cvba, used with kind permission

RF KNX-RF has the same lower layers as wireless M-Bus KNX RF 868 MHz, multiple channels New version of standard just released Improvement in battery lifetime and performance improvement in noisy environment

ZigBee is a ed Trademark of the ZigBee Alliance

© Radiocrafts AS

ZigBee basics Short range radio based on IEEE 802.15.4 2.4 GHz Mesh radio Limited to 10 mW/MHz in Europe by EN 300 328

ZigBee Smart Energy Public Application profile for of Meters Display Repeater Load Control Devices Demand response Security to allow consumer only, utility only, or shared networks

ZigBee Smart Energy : Preferred solution in US. for Smart Energy HAN

Smart Energy Security  Security is critical requirement  AES128 bit network key and link keys  Preconfigured link key  Used to receive network key

 Certificate based public key exchange to achieve final link key  Utilizes a Certificate Authority for the device keys  Process has been independently audited and approved by Carnegie-Mellon

The way forward: ZigBee IP stack New ZigBee stack option in development Based on end to end IP for smart metering MAC – 15.4 2006 with MAC security 6LoWPAN

6LoWPAN Standardized through IETF IPv6 packets over Low power Wireless Personal Area Network Compression, fragmentation++ ROLL (Routing Over Low power and Lossy networks ) Radiocrafts is working with 6LoWPAN leader Sensinode

RC2400/RC2400HP  ZigBee Smart Energy and ZigBee PRO 256 kB Flash Excellent range 102 dB system gain – RC2400 110 dB system gain – RC2400HP(European setup)

Excellent battery lifetime RC2400 and RC2400HP pin compatible

FW options ZigBee Network Module Include precompiled ZigBee PRO stack UART/SPI to external processor

ZigBee 2007/PRO compliant stack available for free of charge Easy-to-use development environment for customers to develop their own solution

Customer tailored solution

RC2400-ZNM MCU

 Application  Security library

 ZigBee PRO stack  Easy to use API interface via UART/SPI

Total cost of ownership of wireless solutions Finance and logistics

 Supply Chain Management  Interest rate/ROI  Risk/Time to market

Solution maintenance

 Evolution of standards  New and better IC’s  Adding functionality

Manufacturing Design

Bill of material

 Assembly  Manufacturing test  Yield loss  HW  FW  Characterization

Lowest TCO

=

One design – Multiple solutions 868MHz High Power Wireless M-Bus

½ Watt

New!

Wireless M-Bus @ 433MHz

KNX-RF

New!

ZigBee

Customer specific

ZigBee High Power

Questions?

Thank you for your attention www.radiocrafts.com

Visit us at Booth #201